DK AE86 renovation and turbo project

Threaded Mode | Linear Mode

DK AE86 renovation and turbo project - Now driveable

01-26-2009, 12:46 AM

Post: #135

Veiss

Member

Posts: 183
Joined: Jan 2005
Reputation: 0

Hello Lew.

According to my calculations, regarding the airflow in the engine, and my turbo it should be around 280 bhp (at the flywheel) at normal boost, around 1.18 bar (17.7 psi) and then later I'll be adding a boost controller, and an overboost level, and that should give me around 310 bhp. I'll post my plots of my theoretical airflow used by the engine (bare in mind that this is very theoretical, based on an approximation on the base hp output of a 4AGZE, and an approximation on the compression ratio) on the flow chart on the Garrett GT2860RS turbo. Mine is with a 0.64 A/R, but if you go for the 0.86 A/R you would be able to get more hp out of the engine. But at the cost of a bit of loss in low rpm power.

Hope this helps.

Attached File(s) Thumbnail(s)

Regards
Lars Veiss, Denmark
Currently [URL=http://www.aeu86.org/viewtopic/dk-ae86-renovation-and-turbo-project---now-driveable/t/2474/start=150[/URL]

« Next Oldest | Next Newest »

Messages In This Thread

DK AE86 renovation and turbo project - Now driveable - Veiss - 01-07-2006, 11:57 PM

[] - Veiss - 01-08-2006, 12:00 AM

[] - nmwisima - 01-08-2006, 02:39 AM

[] - Veiss - 01-08-2006, 01:38 PM

[] - nmwisima - 01-08-2006, 01:47 PM

[] - Veiss - 01-08-2006, 05:39 PM

[] - nmwisima - 01-08-2006, 08:57 PM

[] - Veiss - 01-09-2006, 06:49 PM

[] - nmwisima - 01-09-2006, 07:08 PM

[] - Erik_dk - 01-09-2006, 07:56 PM

[] - banpei - 01-09-2006, 11:04 PM

[] - Veiss - 01-09-2006, 11:30 PM

[] - banpei - 01-10-2006, 10:50 PM

[] - KrizKH - 01-11-2006, 05:43 PM

[] - Veiss - 01-11-2006, 07:04 PM

[] - nmwisima - 01-11-2006, 09:48 PM

[] - Ivan141 - 01-12-2006, 10:15 AM

[] - Veiss - 01-19-2006, 03:33 PM

[] - Veiss - 01-20-2006, 09:04 PM

[] - Veiss - 01-28-2006, 01:52 AM

[] - banpei - 01-28-2006, 11:07 AM

[] - Veiss - 01-28-2006, 11:18 AM

[] - banpei - 01-28-2006, 11:24 AM

[] - Veiss - 01-28-2006, 12:26 PM

[] - Veiss - 04-11-2006, 11:14 AM

[] - Veiss - 04-17-2006, 02:46 PM

[] - Mux213 - 04-17-2006, 02:54 PM

[] - Veiss - 04-17-2006, 03:06 PM

[] - Jan Pedersen - 04-17-2006, 06:20 PM

[] - Veiss - 04-17-2006, 06:27 PM

[] - Veiss - 05-28-2006, 06:41 PM

[] - Jan Pedersen - 05-28-2006, 07:56 PM

[] - banpei - 05-28-2006, 08:22 PM

[] - El_Camino - 05-28-2006, 11:38 PM

[] - nmwisima - 05-29-2006, 12:35 PM

[] - Veiss - 05-29-2006, 02:39 PM

[] - cannabolic - 05-30-2006, 09:33 AM

[] - BOOMEX - 05-30-2006, 02:26 PM

[] - Veiss - 05-30-2006, 04:18 PM

[] - Veiss - 06-05-2006, 07:41 PM

[] - Veiss - 10-20-2006, 09:21 PM

IT'S ALIVE! - Veiss - 05-29-2007, 06:24 PM

[] - Juhler - 05-29-2007, 08:34 PM

[] - Veiss - 05-29-2007, 08:50 PM

[] - Juhler - 05-29-2007, 08:55 PM

[] - Veiss - 05-29-2007, 09:29 PM

[] - Juhler - 05-29-2007, 09:57 PM

[] - Veiss - 05-29-2007, 10:21 PM

[] - Veiss - 07-12-2007, 11:06 PM

[] - Onyx - 07-12-2007, 11:25 PM

[] - Jan Pedersen - 07-13-2007, 06:47 AM

[] - Veiss - 07-14-2007, 02:21 AM

Back on track - Veiss - 02-02-2008, 10:45 AM

[] - Veiss - 02-03-2008, 12:42 PM

[] - Ivan141 - 02-03-2008, 01:46 PM

[] - Veiss - 02-03-2008, 07:55 PM

[] - Jan Pedersen - 02-03-2008, 08:28 PM

[] - Veiss - 02-03-2008, 08:38 PM

[] - Jan Pedersen - 02-04-2008, 08:22 AM

[] - Veiss - 02-07-2008, 02:27 PM

[] - Jan Pedersen - 02-07-2008, 08:34 PM

[] - Veiss - 02-12-2008, 07:14 PM

[] - grothae86 - 02-12-2008, 07:23 PM

[] - Veiss - 02-13-2008, 09:20 PM

[] - Veiss - 02-15-2008, 10:01 AM

[] - Veiss - 02-15-2008, 10:40 AM

[] - Veiss - 02-15-2008, 10:26 PM

[] - Veiss - 03-11-2008, 10:44 AM

[] - Veiss - 03-11-2008, 10:50 AM

[] - Jan Pedersen - 03-11-2008, 10:51 AM

[] - Veiss - 03-11-2008, 10:53 AM

[] - Jan Pedersen - 03-11-2008, 10:58 AM

[] - Veiss - 03-11-2008, 10:59 AM

[] - Veiss - 03-11-2008, 11:30 AM

[] - grothae86 - 03-11-2008, 12:00 PM

[] - Veiss - 03-11-2008, 12:05 PM

[] - Jan Pedersen - 03-11-2008, 12:52 PM

[] - BOOMEX - 03-12-2008, 09:08 AM

[] - Veiss - 03-12-2008, 09:16 PM

[] - Veiss - 03-16-2008, 08:08 PM

[] - banpei - 03-16-2008, 10:13 PM

[] - Veiss - 03-17-2008, 10:23 AM

[] - Veiss - 03-29-2008, 12:51 AM

[] - Veiss - 03-29-2008, 12:53 AM

[] - grothae86 - 03-29-2008, 10:50 AM

[] - Veiss - 10-26-2008, 08:36 PM

[] - Veiss - 10-26-2008, 08:37 PM

[] - Veiss - 10-26-2008, 08:45 PM

[] - Jan Pedersen - 10-26-2008, 10:19 PM

[] - Veiss - 10-26-2008, 10:29 PM

[] - Veiss - 10-26-2008, 10:47 PM

[] - Veiss - 10-26-2008, 11:05 PM

[] - Veiss - 10-26-2008, 11:08 PM

The Colour - Veiss - 10-26-2008, 11:26 PM

[] - banpei - 10-26-2008, 11:38 PM

[] - BOOMEX - 10-27-2008, 06:34 AM

[] - Ivan141 - 10-27-2008, 09:11 AM

[] - vladx_kc - 10-27-2008, 09:18 PM

[] - Veiss - 10-27-2008, 10:54 PM

[] - Veiss - 10-28-2008, 11:16 PM

[] - Veiss - 10-29-2008, 03:39 PM

[] - |BUDA| - 10-29-2008, 03:42 PM

[] - Veiss - 10-31-2008, 06:04 PM

[] - Veiss - 11-07-2008, 05:51 PM

[] - Ivan141 - 11-07-2008, 09:04 PM

[] - robokill - 11-07-2008, 11:47 PM

[] - Veiss - 11-08-2008, 01:36 AM

[] - Gtsi-R - 11-08-2008, 11:43 AM

[] - Veiss - 11-22-2008, 12:20 PM

[] - Ivan141 - 11-22-2008, 01:26 PM

[] - Roku_trueno - 11-24-2008, 06:21 PM

[] - robokill - 11-24-2008, 11:41 PM

[] - Veiss - 11-25-2008, 12:54 PM

[] - ToyotaTs - 11-26-2008, 07:05 PM

[] - oldskull - 11-26-2008, 08:48 PM

[] - Veiss - 11-26-2008, 10:34 PM

[] - DJexor - 11-28-2008, 11:01 PM

[] - Gtsi-R - 11-29-2008, 06:51 PM

[] - Veiss - 11-30-2008, 10:28 PM

[] - Veiss - 12-04-2008, 12:03 PM

[] - tolisspi - 12-04-2008, 01:35 PM

[] - Veiss - 12-04-2008, 01:50 PM

[] - Niek - 12-04-2008, 04:16 PM

[] - Veiss - 12-04-2008, 08:00 PM

[] - Niek - 12-04-2008, 08:11 PM

[] - Veiss - 12-04-2008, 09:02 PM

[] - Niek - 12-04-2008, 10:15 PM

[] - Veiss - 12-19-2008, 12:14 AM

[] - gtapex - 12-19-2008, 01:18 AM

[] - Gtsi-R - 12-19-2008, 03:42 PM

[] - Roku_trueno - 12-19-2008, 04:36 PM

[] - Veiss - 01-25-2009, 12:39 PM

[] - Veiss - 01-25-2009, 12:40 PM

[] - Lew - 01-25-2009, 06:49 PM

[] - Veiss - 01-26-2009 12:46 AM

[] - Ozone - 01-26-2009, 02:50 PM

[] - Veiss - 01-27-2009, 05:32 PM

[] - Veiss - 02-12-2009, 12:18 AM

[] - Jan Pedersen - 02-12-2009, 08:06 AM

[] - Veiss - 02-12-2009, 10:30 AM

[] - Veiss - 02-17-2009, 10:41 PM

[] - Veiss - 02-20-2009, 10:40 AM

[] - Veiss - 02-24-2009, 07:24 PM

[] - Jan Pedersen - 02-24-2009, 07:58 PM

[] - robokill - 02-24-2009, 08:01 PM

[] - banpei - 02-24-2009, 09:40 PM

[] - Veiss - 02-26-2009, 08:49 PM

[] - DJexor - 02-26-2009, 10:56 PM

[] - Veiss - 02-27-2009, 10:21 AM

[] - Veiss - 03-06-2009, 12:51 AM

[] - Veiss - 03-08-2009, 11:57 PM

[] - Veiss - 03-20-2009, 03:51 PM

[] - spawns - 10-30-2009, 02:00 PM

[] - Veiss - 01-28-2010, 11:29 PM

[] - JonnyAE86 - 01-29-2010, 12:19 AM

[] - Ivan141 - 01-29-2010, 09:50 AM

[] - Roku_trueno - 01-29-2010, 04:10 PM

[] - Veiss - 01-30-2010, 01:08 AM

[] - BOOMEX - 01-30-2010, 02:05 AM

[] - Kid Karola - 01-31-2010, 12:57 AM

[] - Damn86 - 07-28-2010, 09:02 PM

[] - Gtsi-R - 07-29-2010, 08:10 AM

Possibly Related Threads...
Thread		Author	Replies	Views	Last Post
	@dodo@ Levin Coupe, renovation and tuning (56k think twice)	@dodo@	165	165,777	03-28-2018 12:35 PM Last Post: ZaX
	KE70 4A-GE 16V turbo	kjb	16	30,844	10-21-2016 01:32 AM Last Post: fantapants
	Another AE86, Duracell. Now with VEMS, and cage...	Uzelac	62	90,880	06-22-2015 02:56 PM Last Post: Uzelac
	ae86, 6 speed, turbo	heagney	12	16,818	01-20-2014 06:21 PM Last Post: T_AE86
	4AG 16V Turbo 15PSI Running MegaSquirt 3.0	CHACAMAN	15	24,659	08-14-2013 04:28 AM Last Post: daveskatesallday

User(s) browsing this thread: 6 Guest(s)