AEU86 : EU AE86 Community - AE86 - AE86 : Technical v - been sitting all winter. still won't start. help

been sitting all winter. still won't start. help
03-27-2009, 10:07 PM
Post: #11
banpei Offline
Super Moderator
******
 		Posts: 11,531
Joined: Aug 2004
Reputation: 7
been sitting all winter. still won't start. help
Great to hear it got solved! Thumbs up!
1983 - AE86 Sprinter Trueno - import project
2013 - Honda Civic sport - daily driver
2004 - AEU86 dot ORG - daily domain

Support our forum, buy from the AEU86 shop:
[Image: AEU86 AE86 - been sitting all winter. st...tart. help]
Visit this user's website Find all posts by this user
03-27-2009, 11:08 PM
Post: #12
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
ugh, not quite i guess.

went out to start it again to let it warm up for a while. turned it over, fired fine. then accidentally tapped the throttle, stalled. and now my fuel pump isn't working again. (it'll make a whirring noise when in acc) replaced all fuses that i did before again, still nothing.

could i have flooded it and could there be a sensor that won't let the pump work until it's cleared?
Find all posts by this user
03-28-2009, 02:02 AM
Post: #13
jondee86 Offline
Posting Freak
*****
 		Posts: 947
Joined: Apr 2007
Reputation: 1
been sitting all winter. still won't start. help
Check your AFM flapper is not stuck in the fully closed position. It has
to move when you are cranking, to open a switch. That switch turns the
fuel pump on. With the ignition on, your should hear the pump start if
you poke the flapper with your finger.

Cheers... jondee86
Find all posts by this user
03-28-2009, 09:37 PM
Post: #14
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
pretty sure i don't have one since it's inducted with velocity stacks



[Image: AEU86 AE86 - been sitting all winter. st...tart. help]
Find all posts by this user
03-29-2009, 03:18 AM
Post: #15
jondee86 Offline
Posting Freak
*****
 		Posts: 947
Joined: Apr 2007
Reputation: 1
been sitting all winter. still won't start. help
Nope... no factory airbox, no AFM and no flapper !!!

Maybe the fuel pump is switched by the Circuit Opening Relay, just as
it was with the original GTS engine ? But I don't know what ECU you
are running or how your car is wired. If it worked last year, and you
have actually had it running, it is just a case of back tracking the fuel
pump power circuit until you find a loose connection, short or broken
wire.

Cheers... jondee86
Find all posts by this user
03-30-2009, 12:54 AM
Post: #16
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
yeah it was running after i changed all the fuses. and stopped working a few starts after. it's running a blacktop ECU on a 1st gen silvertop. you can hear the fuel pump prime in acc when its working and it stopped priming after a few starts. so i think i'm just gonna take a volt meter to the connection to the fuel pump. if there's power, then its the pump. if not, then its the wiring.
Find all posts by this user
03-30-2009, 10:31 PM
Post: #17
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
btw, the open circuit relay is bypassed. i tested for voltage at the pump harness and it reads 12v strong so i guess i need a new fuel pump.
Find all posts by this user
04-06-2009, 03:42 AM
Post: #18
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
so....it wasnt the pump. one of the ground broke off the assembly. so i rewired everything. tested it with the pump in the tank. worked. put the tank back on. put gas back in it, doesnt work anymore.

any ideas?
Find all posts by this user
04-09-2009, 02:56 PM
Post: #19
shorestyle Offline
Junior Member
**
 		Posts: 14
Joined: Mar 2009
Reputation: 0
been sitting all winter. still won't start. help
well i swapped the fuel pump with a brand new one and no more issues!
Find all posts by this user
04-11-2009, 02:34 PM
Post: #20
banpei Offline
Super Moderator
******
 		Posts: 11,531
Joined: Aug 2004
Reputation: 7
been sitting all winter. still won't start. help
So it was a combination of ground, fuses and fuel pump?
1983 - AE86 Sprinter Trueno - import project
2013 - Honda Civic sport - daily driver
2004 - AEU86 dot ORG - daily domain

Support our forum, buy from the AEU86 shop:
[Image: AEU86 AE86 - been sitting all winter. st...tart. help]
Visit this user's website Find all posts by this user


Possibly Related Threads...
Thread Author Replies Views Last Post
  Refreshed 20v blacktop first start.. Mylesmck 6 516 10-07-2024 07:55 AM
Last Post: Ivan141
  PWR light issue and no brake fluid after winter storage magpie 10 2,367 05-25-2023 08:09 AM
Last Post: Bean
  Warm start problem DJexor 5 2,159 03-09-2023 10:15 AM
Last Post: Ivan141
  Winter tires Ryo 7 5,124 01-30-2020 05:33 AM
Last Post: oldeskewltoy
  Weak spark, doesn’t start. AlexFourTwenty 4 14,860 12-12-2017 03:35 AM
Last Post: AlexFourTwenty

Forum Jump:


User(s) browsing this thread: 2 Guest(s)

Contact Us | AEU86 | Return to Top | Return to Content | Lite (Archive) Mode | RSS Syndication